Firstly, aim to make choices for the good of the whole. Follow Biohazardous Spills guidance for spills involving biohazards. 7. More and more organizations attach the same importance to high standards in EHS management as they do to . Treatment for any non-life threatening work-related . Scope Plastic Spill Trays. Environmental Health and Safety 2408 Wanda Daley Drive Ames, IA 50011-3602. [email protected] 515-294-5359 phone Disinfectants The key is to follow proper procedures for storing, transferring, handling, using, and disposing of chemicals. To prepare for spills, you should: (1) learn about the hazards of the chemicals in your laboratory, (2) write response procedures to address those hazards, and (3) make sure that you have the equipment and training necessary to follow those procedures. 6. Use paper towels or other absorbent material to wipe up the spill. Those persons involved in the incident should remain in the area outside the involved building to assist the emergency response agencies when needed. . Contain the spill with paper towels or other absorbent material such as bench liners. . In case of alkaline spills neutralise with a weak acid such as boric acid before mop up. Contact EHS at 355-0153 for training or questions. An incidental spill is one that staff can clean up without putting themselves or others in danger. Clear the area. For environmental concerns regarding spills, please contact the Division of Environmental Protection at 301-496-3537. A small-scale spill is generally considered to be 1 liter or less and have a hazard rating of less than 2 in all categories. Spills that can be cleaned up by lab personnel without putting themselves or others in danger. Box Battery Acid Spill Kit, For Laboratory, Chemical/Hazmat 4,500 / Unit. Allow to sit for 15 minutes. Cover the spill completely with absorbent material. You may contact OMS at (301) 496-4411. Hazardous Spill Management. Building a Strong Safety Culture. Two main categories: Major spills. Biological Safety, Laboratory Safety, Clinical Safety T:\Documentation\EHS-Manual\3.4 Biological Spill Planning and Response.docx PAGE: 1 of 18 Biological Spill Planning And Response (EHS Program Manual 3.4) 1.0 Overview Spills of biological materials are potentially hazardous not only to the individual but also to co-workers and people in Chemical Spills. Extra Large Drip Tray 16L Polyethylene with lip SC-FE006. Use Spill Kit if necessary. Chemicals. Wash hands/face with soap and water before and after cleanup. HRD-WHS-GUI-430.2 Chemical Spill Management Guidelines 2015 December Page 1 of 7 . 25 The person in charge (Laboratory Manager) shall ensure that blood spill kits are available whenever blood or blood containing materials are handled. Find here online price details of companies selling Spill Kit. All other spills should be cleaned up by specially trained personnel. Using experienced trainers with hands on knowledge, we take students through all aspects of spill response for hazardous materials in the work environment. The lever action that activates the shower may be linked to another lever that lifts the plug. Call 911 to initiate OESO Chemical Spill Response. See the Spill Management section, page 15, for information on preventing spilled chemicals from spreading. Management of POPs including PCB Waste. Campus Safety Contacts. Secondly, make confident choices. 5. Intervention Reporting and responding properly to a spill once it occurs. Get info of suppliers, manufacturers, exporters, traders of Spill Kit for buying in India. Flood the area with freshly made 1:10 dilution of sodium hypochlorite solution, and let it stand for 15- 20 minutes Wipe up the disinfectant. Spill Kit Planning Guideline WHS-PRO-GUI-010f 1 . Large tissue particles must be removed and placed in an autoclavable biohazard bag prior to spill clean-up. Supremex Equipments. When a small scale chemical spill occurs: Restrict access to area. They can occur at any time and during normal laboratory activities. Laboratory managers shouldverify that all persons are accounted for. Chemical spills and accidents need to be minimized as much as possible. Dispose of all materials safely in accordance with biohazard guidelines. Put on fresh pair of disposable gloves, lab coat and goggles before starting cleanup. Minor Chemical Spill Alert people in the area that a spill has occurred. To initiate this program the University has purchased spill clean-up kits centrally and has Glacial acetic acid and concentrated sulfuric acid were the hazardous materials involved in the incidents. Employees may call 911 to contact OESO for telephone advice or assistance cleaning up the spill. Pick up any pieces of broken glass with forceps and place in a sharps container. Index 8. EH&S plays only a consultation role during small chemical spills. Each Chemical Spill Kit contains one Toolbox/ PPE Spill Kit and two Universal Spill Absorbent Kits. A hospital-grade disinfectant can be used on the spill area after cleaning. High level, broad-spectrum disinfectants. Spill Clean Up Procedures MINIMAL aerosols produced Cover the spill with paper towels Saturate with disinfectant Leave the laboratory until 99% of the airborne particles have been removed. Minor spills. Small, incidental spills. This manual will provide information to help schools establish and maintain Best Management Practices for the If a chemical spill should occur . Polyeco Group were awarded two projects by United Nations Development Program in Mauritius through international tendering procedures. If you're confident lab staff can handle the spill safely, go to Step 4. Wearing gloves and lab coat, cover spill with paper towels, pour disinfectant around the spill allowing it to mix with spilled material. The following general procedures should be followed by laboratory personnel to clean up small spills: Spill Management. First aid kits as size and content may vary upon number of people and particular laboratory situations. Each hazardous material user must be ready and equipped to handle a spill. Purdue Police Phone: (765) 494-8221. Instead: Alert nearby persons about the spill. reduce the number of microorganisms in critical environments to a level at which they do not present a risk to patients or staff. Otherwise, the laboratory worker who will clean-up the spill must follow . All spills must be reported to EHS. Note: For spills greater than 4 liters, call Public Safety at 609-258-3333. So you're all set for spill management in the laboratory environment. Mini Drip tray 1,7L Polyethylene SC-FE001. Control the spill (minimize the quantity released) Contain the spill (into as small an areas as possible) Clean up the spill . Whenever possible, spills of LIQUID hazardous drugs will be handled by employees in the area of the spill. Cover the spill with a newspaper, blotting paper / paper towel or dry mud. Contact List 9 . Leave on for 10 minutes. The projects involved the provision of services for the remediation of soils contaminated with DDT and the destruction of POPs chemicals, DDT contaminated debris and PCB . Discard all disposable materials used to clean up the spill into a biohazard bag. 4. Major Radiation Spill Attend to injured or contaminated persons and remove them from exposure. SPILL KITS. It also explains the most effective methods of spill response in the workplace and how to effectively use a Spill Kit. Requirements for all spills: eye and face protection , and suitable gloves. Close the cabinet and leave the spill undisturbed for 20 minutes. Responsibilities 3. Spill Kit Equipment The Laboratory Chemical Spill Clean Up Procedures were created to give researchers and laboratory personnel a starting point for developing a chemical spill kit and providing guidance for cleaning up chemical spills. -The time to reenter will depend on the air changes per hour (ACH) Wear PPE to clean up Autoclave material Disinfect floors and . Know Your Hazards A chemical spill is the unintentional and uncontrolled release of a chemical, also referred to as a hazardous material, into the . Introduction 2. Spill Response Training is designed to protect workers responding to hazardous spills and limit the potential environmental & financial impacts upon companies. Spill Control Procedures SOP-SCP-01 . The key to safety in the event of a spill is preparation, training, and prevention techniques. Disposable items in the spills kit should be replaced after each use of the kit. Cover acid spill with soda ash or sodium bicarbonate powder and after leaving for sometime use the mop. Place warning signs on the door to the room where the spill occurred. How to handle spills in the laboratory. Extra Large Drip Tray 16L Polyethylene SC-FE005. Dry the area, as wet areas attract contaminants. Groups of people at every institution train to respond to common lab spills. Recent chemical spills encourage review of laboratory practices. Keep small-scale spill kits in every lab for small, incidental chemical spills. To reduce the risk of accidents, store formalin in air-tight containers and keep specimen containers in secondary containment bins. The Lab Standard and Right-to-Know Programs require emergency and spill response training. . Laboratory supervisors must handle small-scale chemical spills in their lab. 2 CDC guidelines recommend removal of bulk spill material, cleaning the site, and then disinfecting the site with a disinfectant effective against the potential agent. More protection may be required when handling particularly hazardous materials such as strong corrosives or rapidly off-gassing chemicals (eg, hydrochloric acid, xylene, formaldehyde). Part 1: Toolbox/ PPE Spill Kit Standard Operating Procedure Spill Control Procedures SOP Number: SOP-SCP-01 Category: Lab Process Supersedes: N/A Effective Date: December 1, 2017 Pages 6 Subject: Spill Control Procedures. A small chemical spill is a volume which does not exceed the capacity of a standard spill kit. Preventing Chemical Spills in the Lab. If you have not been trained to use a particulate respirator , DO NOT attempt to clean up a spill of dry chemotherapy or other powdered hazardous drugs yourself. General guide for ALL biological spills. The process starts with isolating the spill - this can be achieved by sealing off the area and putting up warning signs. The laboratory (1) may opt to clean up its own spills, (2) may initiate the university's emergency response system by calling 911 and reporting a chemical spill, or may (3) institute a combination of the two. Know the three "C's". 2 Prevention of Spills and Leaks Inspection and replacement of hydraulic hoses and This document outlines procedures for the management of laboratory chemical spills that may occur on campus, tominimise the effects on health and safety from exposure to chemical spills Spots or drops of blood or other small spills (up to 10 cm) can easily be managed by wiping the area immediately with paper towels, and then cleaning with warm water and detergent, followed by rinsing and drying the area. There are two types of acids: mineral (inorganic) acidssuch as sulfuric, hydrochloric, or nitricand carboxylic (organic) acids such as formic or acetic. When needed, they will bring more resources than what may be available in the laboratory. Spill Management Small volumes (few drops) of Spills Wear workman's gloves and other PPE appropriate to the task. If the spill could potentially harm someone, call RMS at 702-895-4226 or Public Safety at 911. Intent . For example, laboratories using hydrofluoric acid (HF) must supply calcium gluconate (C 12 H 22 CaO 14) gel in case of skin contact. Put on clean gloves and lab coat. Large Drip Tray 13,5L Polyethylene SC-FE004. All injuries and exposures are required to be reported to Occupational Medical Service (OMS) located in Building 10, Room 6C306. A specified procedure should be adhered to for any transferring of formalin. To increase the availability of chemical spill management supplies a standard chemical spill kit has been identified as a good general purpose product for use for the management of small chemical spills in laboratories within Monash University. Handy Tray 5L Polyethylene SC-FE007. Physical Plant/Caretaking. Of course, the guidance presented here is not gospel. A risk assessment for a chemical or laboratory process must consider emergency situations and must specify the PPE that is required when responding to a spill. (LS3SC14-P7T) This online PowerPoint course covers the hazards presented by spills of hazardous materials in the laboratory. Each WSU laboratory must decide how it will manage hazardous chemical spills. Flood the spill area with disinfectant. The individual (s) cleaning the blood spill need to use the proper personal protective equipment (PPE), e.g. Unintentional and uncontrolled release of a chemical/hazardous material into the environment. Prevention: the best solution It may seem obvious, but the best way to deal with a chemical spill is to avoid having one in the first place. The basic principles for blood or body substance spill management are outlined in the OSHA Bloodborne Pathogens Standard. Please exercise your judgment in all situations! 4 LHWMP - Laboratory Waste Management Guide safety shower is turned on. Spill kits are located in major hallways, stairwells and near elevators. in the Laboratory This material was produced under grant number SH-17035-08-60-F-11 from the Occupational Safety and Health Administration, U.S. Department of Labor.